1. <th id="qicmx"><option id="qicmx"></option></th>
  2. <object id="qicmx"></object>
    1. <code id="qicmx"></code>

      行業動態

      dongtai

      當前位置:網站首頁 > 行業動態 > 正文

      地板漆施工的技術和工藝要求有哪些

      東柏地坪漆 2019-04-10 4706 0

      厚漿型工業地板漆涂料的施工,地板漆施工職員應保證充分的設備、人力以及質料,以保證針對悉數獨立地板區域的拌和以及后續施工過程,都可以一次性接連結束。拌和結束后馬上將質料澆注到已處理好的基層上,平均、遲緩地實施攤敷,抵達要求的厚度,重視不要操作過分。拌和好的質料一定在規章的運用時限內運用,相關運用時限,請參見產物注腳書。

      In the construction of thick slurry industrial epoxy floor coating, the epoxy floor construction staff should ensure adequate equipment, manpower and material to ensure that the mixing of all the independent panel areas and the subsequent construction process can be completed one-time and one-time. Immediately after mixing, the material will be poured onto the treated grass-roots, spread evenly and slowly, reach the required thickness, and pay attention not to operate excessively. Mixed materials must be used within the application time limit of the regulations. For the relevant application time limit, please refer to the product footnote book.

      地板漆施工的技術和工藝要求有哪些

      涂敷后,應馬上運用尼龍釘齒輥對涂層質料實施輥壓,根除纖細的批刮蹤跡,并幫忙釋放空氣。輥壓操作時,應按同樣軌道往復實施。涂層厚度抵達1mm。

      After coating, nylon nail roller should be used to roll the coating material immediately to eradicate the fine scraping trace and help to release air. When rolling operation, the same track should be reciprocally implemented. The thickness of the coating reaches 1mm.

      涂料的配比、拌和、熟化、涂裝空隙等嚴厲產物注腳書上的注腳操作。施工者應做好施工部位、韶光、溫度相對濕度,地板漆表面處理程序、質料實耗的記載,以備覆按。

      The footwork in the footnote book, such as the proportion of the paint, mixing, aging, and coating gaps. Construction site, Shaoguang, temperature and relative humidity, floor surface treatment procedures and material consumption should be well recorded by the builder in order to be covered.

      施工現場的環境溫度應高于5℃,相對濕度應小于85%。涂料粘度過高時,可參加昊盛專用稀釋劑,但不宜超出10%。涂層厚度的測定,可以濕膜測厚儀測定,或在現場安放樣板,一起施工給與檢測。

      The ambient temperature of the construction site should be higher than 5 degrees, and the relative humidity should be less than 85%. When the paint viscosity is too high, it can participate in the special diluent of Ho Sheng, but it should not exceed 10%. The thickness of coatings can be measured by wet film thickness gauge or by placing sample boards on the spot and testing them together.

      一個完整的地板漆漆的施工流程大致可以分為以下幾個要素;

      The construction process of a complete epoxy floor paint can be roughly divided into the following elements.

      素地處理,底涂層,中涂層,批涂層和面涂層,具體操作步驟如下;

      Ground treatment, bottom coating, middle coating, batch coating and surface coating are as follows:

      素地處理

      Vegetarian treatment

      1基礎素地以水泥粉光面或磨石地為準;

      1 the foundation shall be based on cement powder or grindstone.

      2素地需養生28天以上,水份需8%以下方可施工素地如有不平或空鼓需加以除去;

      2. The vegetable land needs to be kept in good health for more than 28 days, and the water content needs less than 8% before it can be removed if there is unevenness or empty drum in the construction of the vegetable land.

      3用環氧砂漿補平地面;

      3 use epoxy mortar to mend the ground.

      4素地之油污需澈底清洗干凈;

      4, oily dirt must be cleaned thoroughly.

      底涂層

      Bottom coating

      1施工前需保持干凈如有雜物粘附需清除依照正確比例將主劑及硬化劑混合,充分攪拌;

      1. Keep clean before construction. If there is debris adhesion, remove and mix the main agent and hardening agent according to the correct proportion and mix them fully.

      2需視地面情況調整適當粘度混合完成材料需4小時以內施工完成;

      2 it is necessary to adjust the proper viscosity and finish the material within 4 hours according to the ground conditions.

      中涂層

      Medium coating

      1施工前需要保持干凈如有雜物粘附需清除依照正確比例將主劑及硬化劑混合,充分攪拌;

      1. Keep clean before construction. If debris adheres, remove and mix the main agent and hardening agent according to the correct proportion and mix them fully.

      2將混合完成的樹脂適量加入石英砂;

      2 add proper amount of resin to the quartz sand.

      3使用鏝刀將材料均勻涂布;

      3 use the trowel to evenly coat the material.

      4混合完成材料需30分鐘以內施工完成;

      4 the mixture will be completed in less than 30 minutes.

      5施工交接處做好交接處理;

      5 transfer handover at construction juncture.

      6中涂層養生硬化時間約8小時以上。

      6 medium coating curing time is more than 8 hours.

      批涂層

      Batch coating

      1依照正確比例將主劑及硬化劑混合,充分攪拌;

      1 mix the main agent and hardener according to the right ratio and stir well.

      1使用批刀將材料涂布均勻;

      1 use batch knife to coat the material evenly.

      2混合完成材料需30分鐘內施工完成;

      2 the mixture will be completed in 30 minutes.

      4批土養生硬化時間約8小時以上;

      The 4 batch of soil curing time is more than 8 hours.

      面涂層

      Surface coating

      1施工前需保持干凈如有雜物粘附需清除;

      1 before construction, it is necessary to keep clean.

      2使用前主劑先攪拌均勻;

      2 use the main agent before mixing.

      3依照正確比例將主劑及硬化劑混合,充分攪拌;

      3 mix the main agent and hardener according to the right ratio and stir well.

      4使用滾筒或鏝刀將材料均勻涂布混合完成材料需30分鐘以內施工完成;

      4 use a roller or trowel to evenly coat the material and complete the material in less than 30 minutes.

      5施工交接處需做好交接處理;

      5 construction handover should be handled well. 

      地板漆施工的技術和工藝要求有哪些

      相關推薦

      • 地板漆在市面應用前景廣闊,地板漆廠家等著發大財吧

        地板漆在市面應用前景廣闊,地板漆廠家等著發大財吧

        環氧地板漆施工在市面的問世,良好的耐磨性同時還具有防水、防塵的特點,大受人們的青睞。同時,地板漆,地面漆,水泥地板漆,廠房水泥地板漆,車間地板漆施工還具有環保的特點,無毒無害,并且還能根據人們的需要設計成不同顏色的風格??梢詳喽?,地板漆,地...

        2019-03-18 3668 0

      • 廠家揭示環氧地坪漆材料的使用細節

        廠家揭示環氧地坪漆材料的使用細節

        深圳坪山環氧水泥地板漆,環氧地坪哪里有做的環氧水泥地板漆材料的使用細節.在環氧地坪施工中難免會用到涂料材料,然而環氧水泥地板漆涂料就會必不可少,像有些涂料材料成分中會含有易燃的化學物質,所以關于地坪在施工中用到的涂料細節就不容忽視了。下面是...

        2019-03-08 3413 0

      • “低污染,高環?!笔黔h氧地坪漆產業必走之路

        “低污染,高環?!笔黔h氧地坪漆產業必走之路

        清溪水泥地板漆,清溪金剛砂地坪清溪水泥地板漆,清溪金剛砂地坪

        2019-03-04 3373 0

      • 地板漆怎么突然起水泡了

        地板漆怎么突然起水泡了

        環氧地坪起水泡多發作在一樓或公開室,有時二樓以上也時有發作,環氧地坪起水泡普通在施工后不久就發現,有的上午鋪貼的環氧空中下午就有水泡。水泡由小到大,不時開展,開展到一定水平后中止。氣溫越高,水泡就越容易發作,開展的速度也越快。水泡外形各異,...

        2019-03-02 3217 0

      • 鋼結構車間地坪涂料,環氧地坪漆涂裝安全技術措施

        鋼結構車間地坪涂料,環氧地坪漆涂裝安全技術措施

        虎門地坪漆施工,長安水泥地板漆,厚街車間地坪油漆

        2019-02-26 843 0

      • 關于地坪漆涂料浮色發花這是為什么

        關于地坪漆涂料浮色發花這是為什么

        水泥地板漆涂料浮色發花是由于差另外顏料外貌張力差別,在自流平水泥地板漆涂膜中遲鈍遷徙聚集,孕育發生不規矩的花斑。差距越大越易浮色,超細粒徑的顏料易浮色。 具有精良的遷徙性,涂料干燥慢及顏基比小易孕育發生浮色發花。在水泥地板漆涂膜中...

        2019-02-20 906 0

      本文暫時沒有評論,來添加一個吧(●'?'●)

      歡迎 發表評論:

      在线无毒免费三级观看,免费三级现频在线观看,三级黄视频免费播放级_香蕉在线手观看视频